Vogelzang International Sentry Coal VG810CL Specifications download pdf

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 1

READ ALL INSTRUCTIONS CAREFULLY

BEFORE STARTING THE INSTALLATION

OR OPERATING THE STOVE. FAILURE

TO FOLLOW INSTRUCTIONS MAY RE-

SULT IN PROPERTY DAMAGE, BODILY

INJURY, OR EVEN DEATH.

NOT

USE THIS STOVE IN A

MOBILE HOME, MANUFACTURED HOME,

TRAILER OR TENT –

NO EXCEPTIONS!

This stove meets

U.S. Test Standard:

UL 1482-1996

SAFETY INSTRUCTIONS

SAFETY NOTICE: IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE/BUILDING FIRE MAY

RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT PER-

MITS, RESTRICTIONS, AND INSTALLATION REQUIREMENTS FOR YOUR AREA.

READ ALL INSTRUCTIONS CAREFULLY.

1. The installation of this stove must comply

with your local building code rulings. Please

observe the clearances to combustibles (see

reference figures 3–5). Do not place furni-

ture or other objects within the clearance

area.

2. Verify that the stove is properly installed

before firing the stove for the first time. Af-

ter reading these instructions, if you have

any doubt about your ability to complete

your installation properly, you must obtain

the services of a professional licensed in-

staller familiar with all aspects of safe

and correct installation. DO NOT use

temporary or makeshift compromises

during installation.

3. DO NOT store coal, kindling, flammable

liquids or other combustible materials too

close to the unit. Refer to certification label

on back of unit and reference figures 3 – 5

in this manual.

4. Do not install this stove in a mobile home,

manufactured home, trailer or tent

(NO EXCEPTIONS! per HUD Federal

Standard: 24 CFR Ch.XX).

5. If any parts are missing or defective, please

notify the dealer or manufacturer immediately.

DO NOT OPERATE A STOVE THAT IS

MISSING ANY PARTS!.

6. Do not tamper with combustion air control

beyond normal adjustment capacities.

7. Always connect this stove to a chimney and

vent to the outside. Never vent to another room

or inside a building. DO NOT CONNECT

THIS UNIT TO A CHIMNEY FLUE SERV-

ING ANOTHER APPLIANCE.

8. DO NOT CONNECT a coal burning stove to

an aluminum Type B gas vent. This is not safe.

Use approved masonry or a UL 103 HT (U.S)

Listed Residential Type and Building Heating

Appliance Chimney. Use a 6” diameter chim-

ney or larger, that is high enough to give a good

draft. (See specifics in installation instructions).

Vogelzang International Corporation

400 West 17th Street

Holland, Michigan 49423

www.vogelzang.com

Phone: 1-616-396-1911 Fax: 1-616-396-1971

SENTRY COAL

™

STOVE

Model VG810CL Owners Manual

(save this manual for future reference)

continued on next page

1 2 3 4 5 6 ... 17 18

Summary of Contents

Page 1 - SENTRY COAL

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 1READ ALL INSTRUCTIONS CAREFULLYBEFORE STARTING THE INSTALLATIONOR OPERATING THE STOVE. FAILURETO FOLLO

Page 2

Page 10 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0OPERATING INSTRUCTIONSTHIS STOVE IS DESIGNED TO BURNCOAL FUEL.Chestnut, egg, stove, or nut-size coal

Page 3 - ASSEMBLY INSTRUCTIONS

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 11Fig. 13Thermostat Adjustment AccessOPERATING INSTRUCTIONS continued …4. Add about 15 pounds of coal a

Page 4 - LOCATING STOVE

Page 12 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0RECOMMENDATIONS FOR BURNINGANTHRACITE COAL1. When burning coal, it is important to maintaina clean ch

Page 5 - LOCATING STOVE continued…

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 13CHIMNEY MAINTENANCECREOSOTE – Formation and RemovalWhen coal is burned slowly, it produces tar andoth

Page 6 - CONNECTOR PIPE INSTALLATION

Page 14 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0PART ORDERING – VG810CL SENTRY COAL™ STOVEWhen ordering missing or replacement parts, always give the

Page 7 - CHIMNEY CONNECTIONS

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 15PART ORDERING – VG810CL SENTRY COAL™ STOVEWhen ordering missing or replacement parts, always give the

Page 8 - Continued on next page

Page 16 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0FLOOR PROTECTOR MATERIAL CALCULATIONSThis stove has been tested for and must be installed on a floor

Page 9

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 17A. Brick MasonryMinimum 3.5-inch thick brick masonry all framed intocombustible wall with a minimum o

Page 10 - OPERATING INSTRUCTIONS

Page 18 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0Vogelzang International Corporation400 West 17th StreetHolland, Michigan 49423www.vogelzang.comPhone:

Page 11 - WHEN HEATER IS HOT!

Page 2 / VG810CL SENTRY COAL™ VGZ-011 / 090705.09. Be sure that your chimney is safelyconstructed and in good repair. Have the chim-ney inspected by t

Page 12

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 3Upper Heat ShieldLower Heat ShieldLegAssemblyASSEMBLY INSTRUCTIONSTOOLSPencil6 foot Folding Rule or Ta

Page 13 - CHIMNEY MAINTENANCE

Page 4 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0CAUTION: KEEP FURNISHINGS AND OTHERCOMBUSTIBLE MATERIALS AWAY FROM THESTOVE.LOCATING STOVE1. The stove

Page 14

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 5LOCATING STOVE continued…FLOOR PROTECTOR FLOOR PROTECTORBACKWALLSIDEWALL14"20" 16"18&qu

Page 15

Page 6 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0CONNECTOR PIPE INSTALLATION1. The crimped end of the stovepipe fits insidethe stove flue collar. Insta

Page 16

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 7CHIMNEY CONNECTIONSThe stove must be connected to either a ma-sonry or manufactured metal chimney buil

Page 17

Page 8 / VG810CL SENTRY COAL™ VGZ-011 / 090705.0Fig. 10 - Chimney Construction Through RoofFig. 11 - Chimney Connection to FireboxThrough Masonry Wall

Page 18 - Steve Vogelzang

VGZ-011 / 090705.0 VG810CL SENTRY COAL™ / Page 9CHIMNEY CONNECTIONS continued …a flue liner and make sure it is in good condition.(A flue liner consis

Comments to this Manuals

No comments

Vogelzang International Sentry Coal VG810CL Specifications

Browse online or download Specifications for Cookers Vogelzang International Sentry Coal VG810CL. Vogelzang International Sentry Coal VG810CL Specifications User Manual

Summary of Contents

Comments to this Manuals