Vogelzang International PB65XL Specifications download pdf

VGZ-003 / 20110524.0 PB65XL / Page 1

READ ALL INSTRUCTIONS CARE-

FULLY BEFORE STARTING THE

INSTALLATION OR OPERATING

THE STOVE. FAILURE TO FOLLOW

INSTRUCTIONS MAY RESULT IN

P R O P ERT Y DA M AGE , BO DI LY

INJURY, OR EVEN DEATH.

SAFETY INSTRUCTIONS

SAFETY NOTICE: IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE/BUILDING FIRE MAY

RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT PERMITS,

RESTRICTIONS, AND INSTALLATION REQUIREMENTS FOR YOUR AREA.

READ ALL INSTRUCTIONS CAREFULLY.

1. The installation of this stove must comply

with your local building code rulings. Please

observe the clearances to combustibles (see

reference ﬁgures 2 – 4).

2. Do not install this stove in a mobile home,

manufactured home, trailer or tent

(NO EXCEPTIONS! per HUD Federal

Standard: 24 CFR Ch.XX).

3. Verify that the stove is properly installed

before ﬁring the stove for the ﬁrst time.

After reading these instructions, if you have

any doubt about your ability to complete

your installation properly, you must ob-

tain the services of a professional licensed

installer familiar with all aspects of safe

and correct installation. DO NOT use

temporary or makeshift compromises

during installation.

4. If any parts are missing or defective, please

notify the dealer or manufacturer immedi-

ately. DO NOT OPERATE A STOVE THAT

IS MISSING ANY PARTS!.

5. Do not tamper with combustion air control

beyond normal adjustment capacities.

6. Always connect this stove to a chimney and

vent to the outside. Never vent to another room

or inside a building. DO NOT CONNECT

THIS UNIT TO A CHIMNEY FLUE SERV-

ING ANOTHER APPLIANCE.

7. DO NOT CONNECT a wood burning stove

to an aluminum Type B gas vent. This is not

safe. Use approved masonry or a UL 103 HT

Listed Residential Type and Building Heat-

ing Appliance Chimney. Use a 6” diameter

chimney or larger, that is high enough to give

a good draft. (See speciﬁcs in installation

instructions).

8. Be sure that your chimney is safely con-

structed and in good repair. Have the chimney

inspected by the ﬁre department or a qualiﬁed

inspector. Your insurance company should be

able to recommend a qualiﬁed inspector.

9. Creosote or soot may build up in the chimney

Vogelzang International Corporation

400 West 17th Street

Holland, Michigan 49423

www.vogelzang.com

Phone: 1-616-396-1911

Fax: 1-616-396-1971

continued on next page

RailRoad Potbelly stove

Model PB65XL Owners Manual

(save this manual for future reference)

DO Not USE THIS STOVE IN A

MOBILE HOME, MANUFACTURED HOME,

TRAILER OR TENT — NO EXCEPTIONS!

NOTE: THIS STOVE IS

Not A UL LISTED STOVE.

1 2 3 4 5 6 ... 13 14

Summary of Contents

Page 1 - RailRoad Potbelly stove

VGZ-003 / 20110524.0 PB65XL / Page 1READ ALL INSTRUCTIONS CARE-FULLY BEFORE STARTING THE INSTALLATION OR OPERATING THE STOVE. FAILURE TO

Page 2

Page 10 / PB65XL VGZ-003 / 20110524.0OPERATING INSTRUCTIONS continued …more open, the faster and hotter the ﬁre will burn. Do not over ﬁre the stove.

Page 3 - ASSEMBLY INSTRUCTIONS

VGZ-003 / 20110524.0 PB65XL / Page 11MAINTENANCE & SERVICE continued …STOVE JOINTS – Required Tune-up. This stove is manufactured with c

Page 4 - LOCATING STOVE

Page 12 / PB65XL VGZ-003 / 20110524.0PARTS LIST – PB65XL RAILROAD POTBELLY STOVEWhen ordering missing or replacement parts, always give the Model Num

Page 5 - LOCATING STOVE continued…

VGZ-003 / 20110524.0 PB65XL / Page 13

Page 6 - CHIMNEY CONNECTIONS

Page 14 / PB65XL VGZ-003 / 20110524.0This Vogelzang heating appliance is safe when installed properly and will provide you with years of service. How

Page 7

Page 2 / PB65XL VGZ-003 / 20110524.0Keep away from a hot stove to avoid burns or clothing ignition. 17. If small children will be in the same

Page 8

VGZ-003 / 20110524.0 PB65XL / Page 3 t o o l s r e q u i r e dCAUTION: STOVE IS HEAVY. MAKE SURE YOU HAVE ADEQUATE HELP AND USE PROPER LIFTI

Page 9 - OPERATING INSTRUCTIONS

Page 4 / PB65XL VGZ-003 / 20110524.036"CORNER CLEARANCES36"LOCATING STOVEProper clearances must be maintained for adequate air circulation

Page 10

VGZ-003 / 20110524.0 PB65XL / Page 5CONNECTOR PIPE INSTALLATIONLOCATING STOVE continued…1. The smooth end of the stovepipe ﬁts over the cast iron ﬂ

Page 11

Page 6 / PB65XL VGZ-003 / 20110524.0CHIMNEY CONNECTIONSThe stove must be connected to either a masonry or manufactured metal chimney built and tested

Page 12

VGZ-003 / 20110524.0 PB65XL / Page 7Fig. 11 - Chimney Construction Through RoofFig. 12 - Chimney Connection to Firebox Through Masonry WallCHIMNEY

Page 13

Page 8 / PB65XL VGZ-003 / 20110524.0CHIMNEY CONNECTIONS continued …CAUTION: Not all ﬁreplaces are suitable for conversion to a wood stove. Check with

Page 14 - MADE IN CHINA

VGZ-003 / 20110524.0 PB65XL / Page 9OPERATING INSTRUCTIONSCAUTION: HOUSE FIRE HAZARDS• DonotstorewooDorcoalonfloorPROTECTOR, UNDERNEATH S

Comments to this Manuals

No comments

Vogelzang International PB65XL Specifications

Browse online or download Specifications for Stoves Vogelzang International PB65XL. Vogelzang International PB65XL Specifications User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Stoves Vogelzang International PB65XL