Vogelzang International VG450ELGB Specifications download pdf

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 1

READ ALL INSTRUCTIONS CAREFULLY

BEFORE STARTING THE INSTALLATION

OR OPERATING THE STOVE. FAILURE TO

FOLLOW INSTRUCTIONS MAY RESULT

IN PROPERTY DAMAGE, BODILY INJURY,

OR EVEN DEATH.

This stove meets

U.S. Test Standard:

UL 1482-1996

SAFETY INSTRUCTIONS

SAFETY NOTICE: IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE/BUILDING FIRE MAY

RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT PERMITS,

RESTRICTIONS, AND INSTALLATION REQUIREMENTS FOR YOUR AREA.

READ ALL INSTRUCTIONS CAREFULLY.

1. The installation of this stove must comply

with your local building code rulings. Please

observe the clearances to combustibles (see

reference gures 1–3). Do not place furni-

ture or other objects within the clearance

area.

2. Verify that the stove is properly installed

before ring the stove for the rst time.

After reading these instructions, if you have

any doubt about your ability to complete

your installation properly, you must ob-

tain the services of a professional licensed

installer familiar with all aspects of safe

and correct installation. DO NOT use

temporary or makeshift compromises

during installation.

3. DO NOT store wood, ammable liquids

or other combustible materials too close to

the unit. Refer to certication label on back

of unit and reference gures 1 – 3 in this

manual.

4. Do not install this stove in a mobile

home, manufactured home, trailer or tent

NO EXCEPTIONS!

(HUD Federal Standard: 24

CFR Ch.XX).

5. If any parts are missing or defective, please

notify the dealer or manufacturer immediately.

DO NOT OPERATE A STOVE THAT IS

MISSING ANY PARTS!.

6. Do not tamper with combustion air control

beyond normal adjustment capacities.

7. Always connect this stove to a chimney and

vent to the outside. Never vent to another

room or inside a building. DO NOT CON-

NECT THIS UNIT TO A CHIMNEY FLUE

SERVING ANOTHER APPLIANCE.

8. DO NOT CONNECT a wood burning stove

to an aluminum Type B gas vent. This is not

safe. Use approved masonry or a UL 103 HT

Listed Residential Type and Building Heat-

ing Appliance Chimney. Use a 6” diameter

chimney or larger, that is high enough to give

a good draft. (See specics in installation

instructions).

Vogelzang International Corporation

400 West 17th Street

Holland, Michigan 49423

www.vogelzang.com

Phone: 1-616-396-1911

Fax: 1-616-396-1971

Frontiersman

™

Woodstove

OWNERS MANUAL

Covers Models VG450EL, VG450ELG & VG450ELGB

(save this manual for future reference)

continued on next page

DO not USE THIS STOVE IN A

MOBILE HOME, MANUFACTURED HOME,

TRAILER OR TENT — NO EXCEPTIONS!

1 2 3 4 5 6 ... 17 18

Summary of Contents

Page 1 - Woodstove

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 1READ ALL INSTRUCTIONS CAREFULLY BEFORE STARTING THE INSTALLATION OR OPERATING THE STOVE. FAILURE

Page 2

Page 10 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0CHIMNEY DRAFTDraft is a function of the chimney, NOT THE STOVE — do not expect the stove

Page 3 - LOCATING STOVE

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 11SERVICE HINTS continued …chimney like water over a dam, beating down the smoke. The top of the c

Page 4 - LOCATING STOVE continued…

Page 12 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0CHIMNEY MAINTENANCECREOSOTE – Formation and RemovalWhen wood is burned slowly, it produces tar an

Page 5 - CONNECTOR PIPE INSTALLATION

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 13ORDERING PARTS - VG450EL FRONTIERSMAN STOVEWhen ordering missing or replacement parts, alw

Page 6 - CHIMNEY CONNECTIONS

Page 14 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0ORDERING PARTS - VG450EL FRONTIERSMAN STOVEWhen ordering missing or replacement parts, always giv

Page 7 - Continued on next page

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 15WIRING DIAGRAM - VG450ELGB FRONTIERSMAN STOVEWhen ordering missing or replacement parts, a

Page 8

Page 16 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0FLOOR PROTECTOR MATERIAL CALCULATIONSThis stove has been tested for and must be installed on a o

Page 9 - OPERATING INSTRUCTIONS

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 17A. Brick Masonry Minimum 3.5˝/89mm thick brick masonry all framed into com-bustible wall with

Page 10 - SERVICE HINTS

Page 18 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0Vogelzang International Corporation400 West 17th StreetHolland, Michigan 49423www.vogelzang.comPh

Page 11 - SERVICE HINTS continued …

Page 2 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.09. Be sure that your chimney is safely constructed and in good repair. Have the chimney inspected

Page 12 - CHIMNEY MAINTENANCE

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 3ASSEMBLY INSTRUCTIONS t o o l sSafety Glasses & GlovesPencil6 foot Folding Rule or Tape Mea

Page 13

Page 4 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0required, utilizing either a recently cleaned and inspected 6” masonry chimney or a 6” i.d

Page 14 - DISCARD BROKEN GLASS SAFELY

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 5Fig. 3a – FRONT VIEW Minimum Clearance Dimensions from Combustible SurfacesFig. 3b – SIDE VIEW M

Page 15

Page 6 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0CHIMNEY CONNECTIONSThe stove must be connected to either a ma-sonry or manufactured metal chim

Page 16

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 7Fig. 8 - Chimney Construction Through RoofFig. 9 - Chimney Connection to Firebox Through Masonry

Page 17

Page 8 / VG450EL FRONTIERSMAN™ VGZ-014 / 20110519.0CHIMNEY CONNECTIONS continued …ue liner and make sure it is in good condition. (A ue liner consi

Page 18 - Steve Vogelzang

VGZ-014 / 20110519.0 VG450EL FRONTIERSMAN™ / Page 9OPERATING INSTRUCTIONSWARNING: EXPLOSION HAZARD• Never use chemicals, gasoliNe, GASOLINE-TY

Comments to this Manuals

No comments

Vogelzang International VG450ELGB Specifications

Browse online or download Specifications for Stoves Vogelzang International VG450ELGB. Vogelzang International VG450ELGB Specifications User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Stoves Vogelzang International VG450ELGB